| Kawi2strokes.com Forum http://kawi2strokes.com/forum/ |
|
| s2 clutch stuck http://kawi2strokes.com/forum/viewtopic.php?f=2&t=2658 |
Page 1 of 2 |
| Author: | *ryan [ Mon Mar 05, 2012 9:58 am ] |
| Post subject: | s2 clutch stuck |
well went to start up the bikes to take them for a short ride to fill them up and get the fluids moving the gs1100ez started right up ran great the s2a started aswell but when i put it into gear it died right off got it moving with starting in N, rolling it and then shifting into 1st drove about 1/2 a mile around my property varied the throttle still the clutch was stuck clutch lever moves like normal i can see the cable shield moving a little when i pull on it but will not disengage any suggestions? |
|
| Author: | Jim [ Mon Mar 05, 2012 10:17 am ] |
| Post subject: | Re: s2 clutch stuck |
Was it disengaging properly previously? Sticking after sitting for a long time is common. Often if that's the case, you can un-stick it by kick starting with the clutch lever fully squeezed. Other methods include driving around holding the lever in and running hard, and taking the clutch cover off and prying the plates apart. Other reasons for not disengaging include incorrect adjustment, either at the lever or at the actuator. |
|
| Author: | *ryan [ Mon Mar 05, 2012 2:30 pm ] |
| Post subject: | Re: s2 clutch stuck |
all was working when parked for winter will try some more riding to unstick them |
|
| Author: | Zambia [ Mon Mar 05, 2012 2:48 pm ] |
| Post subject: | Re: s2 clutch stuck |
*ryan wrote: all was working when parked for winter will try some more riding to unstick them This should work (did on my S3) but hold the clutch lever in. |
|
| Author: | *ryan [ Mon Mar 05, 2012 3:15 pm ] |
| Post subject: | Re: s2 clutch stuck |
i was riding around in 1st and pulling the clutch in and holding it and letting it out still was stuck after the 1/2 mile ride i did in 1st |
|
| Author: | 650hardtail [ Mon Mar 05, 2012 3:22 pm ] |
| Post subject: | Re: s2 clutch stuck |
what lube ya running in the trans ? my h2 sticks sometimes-but a lil ride always breaks it free |
|
| Author: | *ryan [ Mon Mar 05, 2012 3:38 pm ] |
| Post subject: | Re: s2 clutch stuck |
i believe its Valvoline 10w40 momo cycle oil just changed the oil in my gs, to mobil 1 synthetic 10w40 bought enough to do the s2 aswell but wanted to get the oil warmed first |
|
| Author: | Ja-Moo [ Mon Mar 05, 2012 3:55 pm ] |
| Post subject: | Re: s2 clutch stuck |
ONLY use 2 stroke tranny oil in your bike. You will go from sticking to slipping with 4 stroke oil. |
|
| Author: | *ryan [ Mon Mar 05, 2012 4:07 pm ] |
| Post subject: | Re: s2 clutch stuck |
ive never seen or even heard of a 2stroke tranny oil befor |
|
| Author: | Ja-Moo [ Mon Mar 05, 2012 4:53 pm ] |
| Post subject: | Re: s2 clutch stuck |
*ryan wrote: ive never seen or even heard of a 2stroke tranny oil befor Just ask for it. Motul and belray make it among other...... |
|
| Page 1 of 2 | All times are UTC - 5 hours |
| Powered by phpBB® Forum Software © phpBB Group http://www.phpbb.com/ |
|